Looking for:
Sw6de water heater manual |
Suburban 6 Gallon RV DSI & V Water Heater SW6DE A E – United RV.
Installation of this appliance must be made in accordance withthe written instructions provided in this manual. No agent, representativeor employee of Suburban or other person has the authority to change,modify or waive any provision of the instructions contained in this manual.
CAUTION: If possible, do not install the water heater to where the vent canbe covered or obstructed when any door on the trailer is opened. If this isnot possible, then the travel of the door must be restricted in order toprovide a 6" minimum clearance between the water heater vent and any doorwhenever the door is opened. CAUTION: Due to the differences in vinyl siding, this appliance should notbe installed on vinyl siding without first consulting with the manufacturer ofthe siding or cutting sw6de water heater manual siding away from the area around нажмите сюда appliance vent.
This appliance is not to be installed under any overhang. It mustbe free and clear of any type overhang. This installation must conform with the requirements of the authority havingjurisdiction or in the absence of such requirements with the latest edition of theNational Fuel Gas Code ANSI Z In Canada the installation should conform with the following st and ards. For installation in Recreational Vehicle1. Electrical - CSA st and ard C For installation in Mobile Housing1.
The appliance shall be disconnected from the gas supply piping system during anypressure testing of the system. The appliance and its gas connections shall be leak tested before placing theappliance in operation. All air for combustion must be supplied from outside the structure.
Air forcombustion must not be supplied from occupied spaces. Provide room for access to rear of heater for servicing. Provide an opening flush with floor посетить страницу источник outer wall of coach as shown.
W all of coachshould be framed as shown in Figure 1. Maintain inside dimensions listed below. Do not install on carpet unless the carpet is covered by a metal or wood shieldcovering the entire area underneath the water heater. If you prefer, you may cutaway the carpet from this area. Position heater into framed opening as illustrated.
Slide unit into opening untilthe front of the control housing is sw6de water heater manual with the exterior coach skin. Secure the control housing to the coach wall framed opening at the top and sides of control housing compartment using screws or other suitable fasteners. The doorframe, when installed, must not overlap жмите сюда screw or other fastener head. If dueto the wall thickness, it is not possible to secure the water heater without coveringthe fastener head with the door frame, it is important sw6de water heater manual not over tighten thefastener and distort the control housing.
Over tightening of the fastener may cause water heater leaks between the control housing and the door frame. NOTE: Caulk around screw or fastener heads to assure water tight seal. Install chocks, one sw6de water heater manual each side of water heateras illustrated in Figure 1A. On mesa or yoder type sidewalls, flatten the wall area around the opening. Caulk around framed opening trailer skin as illustrated.
Caulk around door frame using sw6de water heater manual beads of silicone caulking or suitablecaulking - one on flange to seal to control housing and one around back side offrame to seal to coach skin. See detail A in illustration. Insert door frame into control housing and secure with three 3 No. To install door, place the two holes sw6de water heater manual the bottom of the door over the door pinson the frame.
Close the door so that the latch protrudes through the slot in thedoor. Turn latch 90 degrees to fasten door. It is to be permanently mounted by the installer.
The module board must be mounted to where it is accessible for service yet outof way of children. It should be located in a place where it cannot be subjected tomoisture, cleaning chemicals, flammable vapors and liquids, etc.
The board and all wiring to the board must be protected in order to pre vent damages and accidental contact with these parts. The module board may bemounted with two 2 No. Lay a bead of silicone caulking or suitable caulking around the inner edge ofthe control housing top, bottom and sides. This willseal frame to sw6de water heater manual housing.
Apply a bead of silicone caulking or suitable caulking around back side ofdoor frame. This will seal frame to coach skin.
Fit the door frame into control housing over the caulking already applied and pull frame tight to control housing using the three 3 No. Push water heater into framed opening until back side of sw6de water heater manual frame nowattached to control housing is against the side of the coach and firmly attach withscrews around the perimeter of the frame.
Sw6de water heater manual door to frame as illustrated. Close the door so that the door latch protrudes through the slot in the door. Figure 1Figure 1A2. W ater connections are made at the rear of the water heater. NOTE:Inside each fitting is a plastic fill tube. Its purpose is to enhance water circulation. For ease of removal, it is suggested that a pipe union be installed in each water line. Fill tank with water. Open both hot and cold water faucets sw6de water heater manual expel air fromtank.
When tank is filled and water flows from faucets, close both faucets and check all connections for leaks. NOTE: After leak sw6de water heater manual, drain water from tank. When making the gas connection, owners manual the gas fitting on thevalve with a wrench when tightening the flare nut. Failure to hold fitting securecould result in a gas leak due to fitting being damaged. NOTE: It will be necessaryto remove the grommet from the control housing, make the gas connection at thevalve, then reinstall grommet.
It is imperative that grommet and gas line through grommetbe caulked air tight. If not tightly sealed, moisture and potential harmfulflue products could vent through opening and into living area of trailer. See Figure 7. Turn on gas and check all fittings and connections for leaks, using a soap and water solution. Correct even the slightest leak immediately.
Do not use an open flame to check for leaks! Operation abovethis elevation may require derating auriculotherapy manual free download 4 percent for every 1, feet above sealevel. For example, at 8, feet, the water heater should be deratedapproximately 32 percent.
If the unit is not properly derated, lack of sw6de water heater manual oxygen for combustion mayproduce improper burner operation. Pilot outage caused by burner lift-off orsooting from a yellow burner may occur sw6de water heater manual the possibility of carbonmonoxide. You may also notice a lack of efficiency in heating the water becauseof incomplete combustion of the burner at these higher altitudes.
Consult with the local gas company, your dealer, an RV service agency orSuburban Manufacturing Company for proper derating of the unit. Sw6de water heater manual ofthe orifice derating should be done by the dealer or a qualified service agency.
NOTE: It is njdot design that once the unit has returned to lower elevation below4, feetthis high altitude deration and pilot adjustments if equipped bereversed for proper operation of the unit. Refer to Figure 2 for location of D. Refer to Figure 5 and 6 sw6de water heater manual location of D. The electrical connections must be made in accordance with local codes and regulations. Make the 12 Volt D. If the power supply is to be from a convertor, we recommend that the convertersystem /19143.txt wired in parallel with the battery.
This will serve two purposes Provide a constant voltage supply2. Filter any A. Check all connections for water leaks and proper water circulation throughmotor-aid heat exchanger, with engine running. The system should be checked annually for deterioration of heater hose and hoseconnections.
Replace as needed. Refer to Figure 2 for location of A. Refer toFigure 6 for A. Check rating plate and wiring diagram Figure 9 sw6de water heater manual proceeding. Install afused safety switch or circuit breaker of adequate capacity помощь set up manually iphone полезная heater and electrical power source.
Attach the black and white wires from the fused switch orbreaker to corresponding colored wires in heater junction box. A green wire froma well grounded source must be attached to the green nut in the sw6de water heater manual box.
Main Burner: Do not allow the burner to burn with a yellow flame, becausesooting will occur. See Safety Warnings. If the burner flame is yellow and has anerratic pattern, shut unit down and contact a qualified service agency.
Do notcontinue operating unit with improper burner flame. See Figure 11 for correct and incorrect burner flame appearance.
Comments
Post a Comment